The cause:
In the starter the outside gear wheel ring of the planetary
gear always drives itself, because the anti-twist plate wore out. The
tip looks now as follows: Between the outside gear wheel ring and the
pressure plate an antifriction bearing shim with the masses 62 X 50 X
0.1 mm is put. I received this disk before four years still with
Yamaha under the part number 156-11563-00. Afterwards over this shim
more pressure is exerted after the assembly on this outside gear wheel
ring, so that even with heating of the starters problem-free
funtkioniert. The shim does not cost the world and the repair is
relatively fast settled.
How to do:
Remove the starter wire from connector (6).
Remove bolt no. (4b)
Then remove both bolts no. (5) and no.(4a).
Loosen the tail (1) and the body (2) but keep them together.
The planetary housing (3) is connected to the engine from the inside.
It will not fall on the floor!
Place shim (7) (Genuine Yamaha no.: 1J7-17537-YO-30) in front of the body.
Attach it with some grease.
Replace all parts in opposite order.
The shims are not originally made for this engine but for a
four-cylinder supersport from the eighties.
This part is maby no more produced.
More on this site : http://www3.sympatico.ca/g.boudreau/LarrysViragos.htm
Fixed: Starter Problems
-
Topic author - Beiträge: 2789
- Registriert: Montag 8. Juli 2002, 17:55
- Vorname: Jörg
- Wohnort: Zürcher Oberland
- Alter: 47
- Kontaktdaten:
Fixed: Starter Problems
- Dateianhänge
-
- DSrawing starter
- Pic2Shims.jpg (51.23 KiB) 1151 mal betrachtet
- DSrawing starter
- Pic2Shims.jpg (51.23 KiB) 1151 mal betrachtet
-
- Starter
- startercure.jpg (17.27 KiB) 1153 mal betrachtet
- Starter
- startercure.jpg (17.27 KiB) 1153 mal betrachtet
Das Leben besteht nicht nur aus "Wünsch dir Was" und einige Entscheidungen sollten einfach akzeptiert werden.
Der schlimmste Fehler, den man im Leben machen kann, ist ständig zu befürchten, dass man einen macht.
– Elbert Hubbard (1856-1915), The Note Book
Der schlimmste Fehler, den man im Leben machen kann, ist ständig zu befürchten, dass man einen macht.
– Elbert Hubbard (1856-1915), The Note Book
Start engine
Thanks for help, all papers send to the dog dealer and the bike will be repaired next thursday. Greetings Jos Werring.